A comparative study of ciliated protozoa communities in activated-sludge plants

Abstract: Ciliated protozoa present in ten activated sludge plants at Madrid (Spain) were identified. The abundance of key groups of ciliates was determined at each plant; attached ciliates made up the most abundant and representative group. Multivariate statistical analysis was employed to study relationships between ciliates and both the physico-chemical and operational parameters of the plants. Partial correlation analysis revealed: (1) The indicator value of attached ciliates in assessing management and performance of the activated sludge process, (2) the relationship of swimming ciliates with short-aged sludges and lower quality effluents and (3) the direct association between swimming-crawling ciliates and bad settlement conditions of the sludge. Factor analysis showed the associations of the most frequent species of ciliates with the operational parameters of the plants, suggesting the indicator value of some of the species: Vorticella striata was related with poor quality of effluent; Aspidisca cicada with stable plant conditions, and Litonotus lamella with a deficiently settling sludge.     

Selective inhibitors of germination of legume seeds in activated sludge compost

Water extracts of the compost produced from activated sludge and coffee residue were found to be selectively inhibitory to seed germination of some legumes. Germination rate of white clover (Trifolium repens L.), red clover (Trifolium pratense L.) and alfalfa (Medicago sativa L.) seeds were reduced to 2, 29 and 73% of the control, respectively, by water extracts of the compost (20 g l^–1). However, the extracts did not show any inhibition to seed germination of sorghum (Sorghum bicolor Moench), African millet (Eleusine coracana Gaertn.), and Komatsuna (Brassica rapa L.) at the same concentration. The inhibitors in the compost extracts were separated by ion-exchange chromatography and reverse-phase high performance liquid chromatography (HPLC) and the inhibitory activities of seed germination were tested with white clover seeds. Five inhibitors were isolated and identified as 3,4-dichlorophenylacetic acid (3,4-DCP), 3,4-dichlorobenzoic acid (3,4-DCB), 3,4,5-trichlorophenylacetic acid, 3,4,5-trichlorobenzoic acid and mono-2-ethylhexylphthalate by ¹H-, ¹³C-NMR spectroscopy and mass spectrometry. The inhibitory activities of some authentic chemicals of the inhibitors and the related compounds were compared. The results indicated that the main inhibitor in the compost could be 3,4-DCB, which was contained at the concentration of 6.58 mg kg^–1 compost and showed the strongest inhibitory effect on seed germination of white clover among the tested compounds.     

Keratinolytic fungi in sewage sludge

Sewage sludge from the Upper Silesia Region of Poland were surveyed for keratinolytic fungi. Out of 100 Petri dishes examined, 89 were positive for these micro-organisms. Altogether, 185 fungal appearances belonging to 10 species were observed. Trichophyton terrestre with its teleomorph Arthroderma quadrifidum, T. ajelloi with A. uncinatum, Microsporum gypseum with Arthroderma sp., and Chrysosporium keratinophilum with Aphanoascus keratinophilus prevailed in the sludges. The sewage treatment technologies together with the sludge structure, humidity and pH were found to be critical factors determining the occurrence of keratinolytic fungi in the sludge environment. The qualitative and quantitative composition of keratinolytic fungi could be a useful tool in evaluation of sludge treatment processes.     

Effect of concentration and environmental form of tetradecenyl succinic acid on its mineralization in soil

Tetradecenyl succinic acid (TSA) is the major component of a detergent builder (C12-C14 alkenyl succinic acid), which is inherently biodegradable. ¹⁴C-TSA was dosed as a component of sewage sludge into a soil with a history of sludge amendment at final added concentrations of 1.5 and 30 mg (kg soil)^-1. In addition, it was dosed to the soil in an aqueous solution to a final added concentration of 30 mg (kg soil)^-1. Dose and form were found to have a pronouced effect on the mineralization kinetics. When dosed in a realistic form and concentration (i.e. 1.5 mg (kg soil)^-1 as a component of sludge), TSA was mineralized at its highest rate and to its greatest extent, and the mineralization half-life was 2.4 days. When dosed at 30 mg (kg soil)^-1 as a component of sludge, mineralization began immediately, and the half-life was 23 days. In contrast, when dosed at this concentration in aqueous solution, the onset of mineralization was preceded by a 13 day lag period and the mineralization half-life was 69 days. Primary biodegradation and mineralization rates of TSA were very similar. Approximately, half the radioactivity was evolved as ¹⁴CO₂, while the remaining radioactivity became non-extractable, having presumably been incorporated into biomass or natural soil organic matter (humics). This study demonstrated that TSA is effectively removed from sludge-amended soils as a result of biodegradation. Furthermore, it showed the effect that dose form and concentration have on the biodegradation kinetics and the importance of dosing a chemical not only at a relevant concentration but also in the environmental form in which it enters the soil environment.     

Materials for the fungus flora of Japan (49)

Two interesting microfungi are described as new to Japan:Talaromyces galapagensis (anam.Penicillium galapagense), isolated from soil in Shizuoka; andPenicillium megasporum, isolated from marine sludge in Nagasaki. Some observations are recorded, particularly on ascomatal initials ofT. galapagensis, which are similar to those described forTalaromyces flavus.(48): Kaneko, S., Mycoscience 36: 359–360, 1995.     

Anaerobic acidogenesis of primary sludge: the role of solids retention time

This research investigates the effect of solids retention time (SRT) on the acid-phase anaerobic digestion of primary sludge. A series of experiments were conducted using two continuous-flow 3-L units with the following configuration: a completely mixed reactor (CMR) with clarifier and solids recycle and an upflow anaerobic sludge blanket (UASB) reactor. Results show that C(2) to C(5) volatile fatty acids (VFA) were the predominant compounds formed. At a constant hydraulic retention time (HRT) of 12 h, variation in SRT from 10 to 20 days resulted in a slight increase in VFA production in both systems, but at a shorter SRT (5 days) a drastic drop in acid production was observed. In addition, the percent distribution of VFA was to some extent affected by the change in SRT. On the other hand, organic matter degradation [measured by the chemical oxygen demand (COD) specific solubilization rate or the percent volatile suspended solids (VSS) reduction] appeared to be independent of SRT, at least in the range investigated. The percent soluble COD in the form of VFA, however, increased steadily with increasing SRT, approaching the 90% level at 20 days. The remaining soluble COD in the effluent from these systems may be mainly attributed to metabolic intermediates and unused soluble substrate. (c) 1994 John Wiley & Sons, Inc.     

Feasibility of expanded granular sludge bed reactors for the anaerobic treatment of low-strength soluble wastewaters

The application of the expanded granular sludge bed (EGSB) reactor for the anaerobic treatment of low-strength soluble wastewaters using ethanol as a model substrate was investigated in laboratory-scale reactors at 30oC. Chemical oxygen demand (COD) removal efficiency was above 80% at organic loading rates up to12 g COD/L . d with influent concentrations as low as 100 to 200 mg COD/L. These results demonstrate the suitability of the EGBS reactor for the anaerobic treatment of low-strength wastewaters. The high treatment performance can be attributed to the intense mixing regime obtained by high hydraulic and organic loads. Good mixing of the bulk liquid phase for the substrate-biomass contact and adequate expansion of the substrate-biomass contact and adequate expansion of the sludge bed for the degassing were obtained when the liquid upflow velocity (V(up)) was greater than 2.5 m/h. Under such conditions, an extremely low apparent K(s) value for acetoclastic methanogenesis of 9.8 mg COD/L was observed. The presence of dissolved oxygen in the wastewater had no detrimental effect on the treatment performance. Sludge piston flotation from pockets of biogas accumulating under the sludge bed occurred at V(up) lower than 2.5 m/h due to poor bed expansion. This problem is expected only in small diameter laboratory-scale reactors. A. more important restriction of the EGSB reactor was the sludge washout occurring at V(up) higher than 5.5 m/h and which was intensified at organic loads higher than 7 g COD/L. d due to buoyancy forces from the gas production. To achieve an equilibrium between the mixing intensity and the sludge hold-up, the operation should be limited to an organic loading rate of 7 g COD/L d. and to a liquid up-flow velocity between 2.5 and 5.5 m/h (c) 1994 John Wiley & Sons, Inc.     

厌氧消化过程的非模型控制

对废水淤泥的厌氧消化处理过程进行了研究．提出了一种基于神经网络的非模型控制方法。多变量控制系统的操作变量为供热量和进水量．被控变量为消化温度和消化污泥排出浓度。证明了控制算法的收敛性。讨论了控制系统的稳定性。仿真结果证实了非模型控制方法的有效性。该方法无需对象的模型．为复杂生化过程的控制提供了一种新途径。     

Cloning and analysis of the polyhydroxyalkanoic acid synthase gene from an Acinetobacter sp.: Evidence that the gene is both plasmid and chromosomally located

Abstract The polyhydroxyalkanoic acid (PHA) synthase gene ( phaC_Ac ) of a species of Acinetobacter isolated from an activated sludge treatment plant was cloned by heterologous complementation in a poly-β-hydroxybutyrate (PHB) negative mutant of Alcaligenes eutrophus . Nucleotide sequence analysis of phaC_Ac revelaed an open reading frame of 1770 bp with potential to encode a 67.7 kDa protein. The deduced amino acid sequence displays high similarity to other PHA synthase proteins. Probing with an internal region of phaC_Ac revealed that the PHA sythase gene may be present in more than one copy and may occur at both plasmid and chromosomal locations in Acinetobacter spp. This is the first organisms for which evidence has been presented to suggest that a gene involved in PHA metabolism is plasmid-encoded. Purification of PHB granules from sucrose gradients identified proteins of 38 kDa, 41 kDa and 64 kDa which may have a role in PHB metabolism.     

Enrichment of homoacetogens converting H2/CO2 into acids and ethanol and simultaneous methane production

An anaerobic granular sludge was enriched to utilize H₂/CO₂ in a continuous gas-fed up-flow anaerobic sludge reactor by applying operating conditions expected to produce acetic acid, butyric acid, and ethanol. Three stages of fermentation were found: Stage I with acetic acid accumulation with the highest concentration of 35 mM along with a pH decrease from initial 6 to 4.5. In Stage II, H₂/CO₂ was replaced by 100% H₂ to induce solventogenesis, whereas butyric acid was produced with the highest concentration of 2.5 mM. At stage III with 10 µM tungsten (W) addition, iso-valeric acid, valeric acid, and caproic acid were produced at pH 4.5–5.0. In the batch tests inoculated with the enriched sludge taken from the bioreactor (day 70), however, methane production occurred at pH 6. Exogenous 15 mM acetate addition enhanced both the H₂ and CO₂ consumption rate compared to exogenous 10, 30, and 45 mM acetate by the enriched sludge. Exogenous acetate was failed to be converted to ethanol using H₂ as electron donor by the enriched acetogens.